January 2001
March 2003
A Publication of the
National Wildfire
Coordinating Group
Sponsored by
United States
Department of
Agriculture
United States
Department of the
Interior
National Association
of State Foresters
PMS 411
NFES 2710
The New
Generation
Fire Shelter
The New
Generation
Fire Shelter
The National Wildfire Coordinating Group (NWCG) has developed this information for the guidance of its member
agencies and is not responsible for the interpretation or use of this information by anyone except the member agencies.
The use of trade, firm, or corporation names in this publication is for the information and convenience of the reader and
does not constitute an endorsement by the National Wildfire Coordinating Group of any product or service to the
exclusion of others that may be suitable.
NWCG
Fire Equipment Working Team
March 2003
Leslie Anderson
Project Leader
Sponsored for NWCG publication by the NWCG Fire Equipment Working Team, March 2003,
in cooperation with the USDA Forest Service Technology and Development Center, Missoula,
MT.
Questions or comments regarding the contents of this publication should be directed to Leslie
Anderson, project leader, USDA Forest Service, Missoula Technology and Development
Center, Missoula, MT. Phone: 406â329â3900 Fax: 406â329â3719
E-mail: landerson@fs.fed.us
Additional copies of this publication may be ordered by mail/fax from: National Interagency
Fire Center, ATTN: Great Basin Cache Supply Office, 3833 South Development Ave., Boise,
ID 83705. Fax: 208â387â5573. Order NFES 2710.
An electronic copy of this document is available at http://www.nwcg.gov/pms/pubs/pubs.htm
The New
Generation
Fire Shelter
The New
Generation
Fire Shelter
ii
Contents
Introduction __________________________________________ 1
Know Your Fire Shelter ________________________________ 2
How the New Generation Fire Shelter Works _______________________ 2
Escape ______________________________________________ 4
Stay Alert ____________________________________________________ 5
Deployment __________________________________________ 6
Selecting Your Deployment Site _________________________________ 6
Deployment Procedures ______________________________________ 13
Get on the Ground ___________________________________________ 17
Water Can Make the Difference ________________________________ 17
Sharing a Shelter ____________________________________________ 17
Group Deployment ___________________________________________ 17
Keep These Items Out of Your Fire Shelter _______________________ 18
Do Not Delay Deployment _____________________________________ 18
During an Entrapment ________________________________ 19
Moving Your Shelter __________________________________________ 19
Conditions Inside the Shelter __________________________________ 19
When to Leave the Shelter _____________________________________ 22
Training ____________________________________________ 23
Training Scenarios ___________________________________________ 23
Practice Fire Shelters ________________________________________ 24
Realistic Training Is Best ______________________________________ 25
Never Train in Live Fire _______________________________________ 25
Visualization ________________________________________________ 25
Inspection and Care __________________________________ 26
Inspection __________________________________________________ 26
Care of the Fire Shelter _______________________________________ 26
Conclusions _________________________________________ 27
Feedback ___________________________________________________ 27
1
T
Introduction
T
he fire shelter is a
mandatory item of personal
protective equipment for all
Federal wildland firefighters and
must be carried on the fireline by
everyone on Federal wildland fires.
State, local, and rural fire
departments may have different
policies regarding the fire shelterâs
use. However, no one who is
required to carry a fire shelter should
go on the fireline without reading,
understanding, and practicing the
recommendations in this booklet.
The fire shelter has been required
equipment for wildland firefighters
since 1977. Since that time, shelters
have saved the lives of more than
300 firefighters and have prevented
hundreds of serious injuries. A new
generation of fire shelter now offers
improved protection from both
radiant and convective heat. Even
so, the shelter will not protect
firefighters under all fire situations.
The fire shelter should be used as a
last resort if planned escape routes
or safety zones become inadequate
and entrapment is imminent.
Carrying a fire shelter should
never be considered an alternative
to safe firefighting. If you are
considering or are asked to take on
a risky assignment because you
have a fire shelter, it is your
obligation to insist that the plans be
changed. Though the new generation
fire shelter offers improved
protection, it is still a last resort and
cannot guarantee your survival.
This booklet will help you learn how
to use the new fire shelter. It:
âą Explains how the fire shelter
protects you
âą Explains the importance of
training and knowing when and
where to deploy the shelter
âą Tells you what to expect during
an entrapment
âą Describes inspection
procedures that will keep worn
shelters off the fireline
What you see in this booklet may be
familiar to you because much of the
guidance for using shelters is
unchanged. Stories related by
firefighters who survived
entrapments using the old shelter
can still help firefighters learn how to
use the new shelter.
This booklet is the reference
document for fire shelters. It is not
intended to stand alone. New and
experienced firefighters should use
the booklet as part of a
comprehensive fire shelter training
program that includes facilitated
discussion and hands-on training.
During training, be sure you
understand the following key points:
âą Carrying a fire shelter is not an
excuse to take risks on the
fireline.
âą Your highest priority is to avoid
entrapment. If entrapment is
imminent, escape if you can.
âą During an escape or
entrapment, protect your lungs
and airways at all costs.
âą Drop your gear as soon as you
realize your escape may be
compromised. Take your fire
shelter and your tool, but drop
all dangerous flammable
objects and drop any items
that may slow your escape.
âą If you are entrapped, get on
the ground before the fire
arrives.
âą Deploy your shelter where
flames will be least likely to
contact it.
âą Once you are inside your
shelter, stay there. Conditions
outside the shelter will be far
worse than those inside.
âą Train with your fire shelter as
though survival is at stake.
Iâm sure we would not have
survived without them.
Entrapment survivor
Carrying a fire
shelter should
NEVER be
considered an
alternative to
safe firefighting.
2
Convective
heat (from
flames and
hot gases),
100 percent
absorbed
Ground
cooling
Radiant heat,
95 percent reflected
Ground
cooling
U
Know Your Fire Shelter
U
nderstanding how the fire
shelter protects you as
well as the factors that
limit its performance will help you
decide how best to deploy your
shelter.
Figure 1âThe new generation fire shelter reflects radiant heat and absorbs convective heat.
How the New
Generation Fire
Shelter Works
The new generation fire shelter
protects primarily by reflecting
radiant heat and trapping breathable
air (figure 1). The new shelter has
two layers. The outer layer is
aluminum foil bonded to woven silica
cloth. The foil reflects radiant heat
and the silica material slows the
passage of heat to the inside of the
shelter. An inner layer of aluminum
foil laminated to fiberglass prevents
heat from reradiating to the person
inside the shelter. When these layers
are sewn together, the air gap
between them offers further
insulation.
The outer layer of foil reflects about
95 percent of the radiant heat that
reaches it. Because only 5 percent
is absorbed into the shelter
materials, the temperature of the
material rises slowly. Unlike radiant
heat, convective heat (from flames
and hot gases) is easily absorbed by
the fire shelter, allowing the
temperature of the material to rise
rapidly. When the material reaches
about 500 °F, the glue that bonds the
layers begins to break down. The
layers can separate, allowing the foil
to be torn by turbulent winds. Without
the foil, the shelter loses much of its
ability to reflect radiant heat. The
silica material will slow heat transfer,
but offers significantly less
protection without the foil.
Types of Heat
Radiant Heat: Radiant heat
travels in a straight line through
space without heating the
space itself. It turns into heat
when it contacts a cooler
surface. When you stand close
to a campfire, radiant heat
warms you. No air movement
is required for the transfer of
radiant heat.
Convective Heat: Convective
heat requires air movement.
Think of it as a blast of hot air.
When flames or hot gases
move past a surface, the hot
air molecules transfer their
heat to that surface. The hotter
the air and the faster the air
movement, the greater the
convective heating.
3
The right side of my shelter delaminated and the foil flipped over onto the left side. I really started to get
burned at that point because the only thing that was on that side of my shelter was the glass mesh. [When]
there was still a tremendous amount of radiant heat coming off the surrounding area, a wind blew the
shelter half back on to the other side, back to where it belonged, and it was like somebody closing a door
on the oven. The radiant heat difference that just that little piece of foil made was absolutely amazing.
Entrapment survivor
Know Your Fire Shelter
The shelters really do an
amazing job of reflecting that
radiant heat. When that shelter
lifted up and you got that
radiant heat directly, and the
convective heat that was
coming [in], it was just an
incredible change in what you
felt in there.
Entrapment survivor
The shelterâs shape allows you to lie
flat. The ground protects the
underside of your body and your
airway is protected as you breathe
the cooler, cleaner air next to the
ground. The shelterâs holddown
straps and wide floor allow you to
hold it down in high winds. You must
be holding the fire shelter down
before the flame front arrives.
You must be
holding the fire
shelter down
before the
flame front
arrives.
4
D
Escape
D
eploying a fire shelter is a
last resort. If entrapment
seems likely, try to escape.
You should always know the location
of your safety zones and escape
routes. Remember, in a true safety
zone, you do not need your shelter
to protect you from heat and smoke.
Crew supervisors must identify
escape routes and safety zones,
and make sure they are known by
their crews. Changing conditions
may compromise planned escape
routes and safety zones, requiring
that new escape routes and safety
zones be identified if work in the
area is to continue.
If you are in an entrapment, protect
your lungs and airway at all costs.
Most firefighters who perish in fires
die from heat that damages their
airway, not from external burns. One
breath of hot gases can damage
your lungs, causing you to
suffocate.
If you feel that entrapment is
imminent, you will have to decide
quickly whether you have time to
escape. You will have to recognize
when your only option is to deploy
your fire shelter. Watch for
deployment areas as you move. If
you cannot reach a safety zone, do
not pass through an effective
deployment site only to get caught
later in a more hazardous area. You
must be decisive. If you are with a
crew, follow the orders given by your
supervisor. If you are in charge, be
sure to give clear instructions and to
make sure they are understood.
Time is critical during an escape. As
soon as you realize your escape
may be compromised, drop your
gear. Take your fire shelter with you.
Keep your tool if there is a chance
you may need it to clear a
deployment site. Drop packs, chain
saws, or anything else that might
slow you down. Firefighters have
died carrying packs and tools while
climbing a hill to escape fires. You
can move up to 30 percent faster
without your gear. This can easily
mean the difference between life and
death in an escape.
Drop any fusees you may be
carrying. Fusees are the most
dangerous items you carry (figure 2).
When wearing shrouds and long-
sleeved T-shirts, firefighters have
worked close enough to radiant heat
to melt goggles and hardhats. These
plastics melt at around 320 °F.
Fusees ignite at 375 °F. Fusees are
just one of the reasons you should
drop your pack as soon as you
recognize danger. In an entrapment
situation, you do not have time to
think about items in your pack that
could be dangerous.
Another reason to drop your pack is
to make it easier to get into your
shelter. The pack can snag on the
shelter as you are getting into it. If
you will be deploying your shelter
nearby, make sure that you toss the
Figure 2âNever take fusees into a fire shelter.
Youâre highest
priority is to
avoid
entrapment.
If you are in an
entrapment,
protect your
lungs and airway
at all costs.
5
Escape
pack far enough that it will not ignite
and burn a shelter.
Face and neck shrouds offer
additional protection against radiant
heat during escape. Shrouds should
not be used to work in areas that are
so hot you could not work there
without them. If shrouds are worn,
they should be attached to the
hardhat for quick deployment when
they are needed. Do not rely on
shrouds to protect your airway from
hot gases.
Stay Alert
When you are escaping an
entrapment, stay alert and be
prepared to act. If the fire is closing
in behind you, get your shelter out
and partially unfold it. Use the
shelter to shield you from the heat if
necessary. Donât drop the shelter,
allow it to blow away, or snag it on
the brush. Be ready to grab the
shelter by an edge and get into it.
Be alert for signs of hot gases.
These gases may not be smoky or
dark. Your only warning may be air
movement, an increase in
temperature, and embers blowing
past. If gases get hot enough to burn
you, it is time to get under your fire
shelter.
As you move along your escape
route, stay alert and talk to other
crewmembers. Talking helps relieve
stress and ensures that hazards are
communicated quickly. Be alert for
deployment areas as you move. If it
becomes apparent that you are not
going to reach a safety zone, keep
in mind that it takes 15 to 20
seconds to deploy a shelter under
ideal conditions, longer in turbulent
winds or while wearing a pack
(another reason to toss the pack).
Leave enough time to get on the
ground and under your shelter before
the heat arrives. Firefighters have
died or been injured because they
waited too long to deploy their
shelters.
While the fire shelter is considered a
last resort, it can also protect you
from falling embers or thick smoke.
You should not hesitate to use your
shelter to protect yourself. Do not
worry about the cost of the fire
shelterâyour safety is always the
highest priority.
As soon as you
realize your
escape may be
compromised,
drop your gear.
6
Deployment
Chimneys
Chimneys
Selecting Your
Deployment Site
The characteristics of an effective
deployment site have not changed.
Your goal in selecting a deployment
site is to keep the fire shelter away
from heat, especially flames.
Practice evaluating deployment sites
(figures 3 to 15) so that you can
recognize them quickly under stress.
Identify effective sites whenever you
are on the fireline so you know
where they are before you need one.
Figure 3âKeep away from narrow
draws, chutes, and chimneys. They tend
to funnel smoke, flames, and hot gases
that can damage your shelter.
Saddle
Saddle
Figure 4âAvoid saddles on ridgetops.
They also funnel smoke and heat.
Deploy your
shelter where
flames will be
least likely to
contact it.
7
Deployment
Convective heat
Con
vec
tive
he
at
Figure 5âTry to pick natural firebreaks
such as wet meadows, wide
streambeds, swampy areas, and
rockslides.
Figure 6âFlat areas on slopes, such as
benches or road cuts, offer some
protection from radiant and convective
heat. These level areas can keep you
below the path of flame and convective
heat. Donât deploy in the middle of a
road if vehicles may be passing. A
drainage ditch on the uphill side of a
road cut can be an effective deployment
site unless it contains fuels that could
ignite and burn the shelter.
Four firefighters deployed their fire
shelters on this road during a burnover.
All four survived with only minor burns.
8
Deployment
w
a
r
D
Figure 7âStay out of draws, even when
deploying on a road.
Stay away from
Stay away from
all fuels
all fuels
Figure 8âDo not deploy in or next to
tall or thick grass, small trees, trees
with low branches, brush, piles of
slash, or firefighting equipment such as
packs, parachutes, tools, or chain saws.
Firefighters have been burned because
they deployed too close to such fuels.
Large rockslides can be effective
deployment sites, but you must stay
away from brush and trees, and from
fuels scattered in the rocks. Even
though it can be difficult to seal the
edges of the shelter in large, jumbled
rocks, rockslides sometimes offer the
largest area free of fuels and may be the
best option for deployment.
9
Deployment
Figure 9âGround fuels, such as grass
or tree litter, can ignite rapidly. Clear the
deployment site to mineral soil if at all
possible. If time is critical, pick a site
with the sparsest fuels.
Figure 10âDeploy fire shelters well
away from thick vegetation such as the
shrubby understory and the trees in
this photograph.
Stay in the
Stay in the
clear away
clear away
from trees
from trees
and brush
and brush
10
Deployment
Figure 11âObjects such as large rocks,
dozers, or structures such as cabins,
can act as barriers to heat. But, if the
objects themselves ignite, you may
have to move. Testing shows that
flames funnel underneath vehicles. Do
not deploy under your vehicle.
Snag
Snag
Figure12âAvoid areas where rocks or
logs can roll on you or snags can fall on
you.
11
Lee s
ide
Flames and hot gases rise above ridge
Fir
e
Figure 13âThe lee side of a ridgetop
can be an effective deployment site
because the flames and hot gases tend
to rise above the ridge. Fire intensity
usually drops when fire reaches a ridge.
But be alert for the possibility that
firebrands might ignite fires below you
on the lee side of the ridge.
Figure 14âWide areas that have been
cleared of fuel, such as dozer lines or
roads, can be good deployment sites,
depending on the size of the area that
has been cleared and the behavior of
the fire.
Deployment
12
Deployment
Figure 15âBurned-out areas can be
effective deployment sites if there is no
fuel left to reburn.
13
Deployment
Procedures
It is important to carry the fire
shelter properly. The case should be
vertical if it is worn on your side or
horizontal if it is worn in the small of
your back under your pack. The
shelter may be carried in the fire
shelter pouch that is a feature of
some field packs. A chest harness
is available that allows persons
operating machinery to carry the
shelter on their chest (figure 16).
Never carry your shelter inside the
main body of your field pack.
If you are part of a crew, your
supervisor will decide where and
when to deploy fire shelters. Follow
orders. If you are not in a crew or
have become separated from your
crew, you must rely on your own
judgment.
Deployment
Figure 16âThe chest harness is preferred by some operators of engines and heavy
equipment.
14
Deployment
After removing your shelter from its
case (figure 17), throw your pack
and any flammable objects, such as
fusees or gasoline, far from the
deployment area. Donât throw them
near others who are deploying their
shelters.
Scrape away ground fuels if time
permits. Clear an area 4 by 8 feet
(larger if you have time) down to
mineral soil. An area cleared of fuels
minimizes flame contact with the
shelter. Never deploy your shelter
immediately downwind or uphill from
a large concentration of fuel. The
heavier the fuel loading, the larger
the fuel break needs to be. Although
the new shelter offers better
protection from direct flame, you will
be more likely to survive if flames do
not contact it.
Pull either red ring on the plastic bag
down to the bottom and up the other
side (figure 18). Remove the shelter.
Figure 18âPull either red
ring to remove the plastic
bag.
Figure 17âUse the pull
strap to remove the
shelter from its case.
15
Deployment
Figure 19âGrasping the
correct shake handles will
speed your deployment.
Pick your deployment site. The
lowest depression on the site is
best. It should be as free of fuels as
possible.
Grasp the shake handles that extend
from the folded shelter. The handles
are marked,
RIGHT HAND
in red
and
LEFT HAND
in black (figure
19). When you have the shake
handles in the proper hands, the
shelter will unfold with the opening
toward your body. Grasping the
wrong handles will not prevent you
from entering the shelter, but it may
slow your deployment by 1 to 2
seconds.
Shake out the shelter (figure 20).
Figure 20âHolding the
shake handles, shake out
your shelter.
16
Deployment
Lie face down so your feet are
toward the oncoming flames. The
hottest part of the shelter will be the
side closest to the advancing fire.
Keep your head and airway away
from these high temperatures (figure
21).
The holddown straps on the new
shelter are sewn into the floor
panels. As soon as you are under
your shelter, slip your arms through
the straps up to your elbows (figure
22).
It is critical to be on the ground and
under the shelter before the fire
arrives.
The new shelter is narrower than the
old shelter and will feel smaller.
Once you are on the ground, push
out the top and sides of the shelter
so it holds as much air as possible.
The air between you and the sides of
the shelter is excellent insulation. Be
sure that the shelter is fully unfolded
and not bunched beneath you when
you deploy.
You do not want to pull your shelter
against you as you would a blanket.
Instead, push the shelter material
away from your body so it wonât burn
you. As you push the shelter
material away from your body, you
also leave more space for cool air.
Hold the shelter down with your feet,
legs, elbows, and hands.
Keep your nose and mouth on the
ground. Temperatures just a few
inches off the ground are
dramatically higher than those at the
surface. Breathing through a dry
bandanna or a shroud will help
reduce the heat and smoke you
inhale.
Figure 22âSlip your hands through the holddown straps up to your elbows.
Figure 21âLie face down with your feet toward the oncoming flames.
Wear gloves inside the shelter.
Without them, you may burn your
hands and be unable to hold down
the shelter. In 1979, a firefighter in
Idaho was killed after his hands were
burned and he was unable to hold
down his shelter.
Wear your hardhat to protect your
head from burns.
17
If you use a face and neck shroud,
pull it into place.
If you have a radio, keep it with you
in the shelter so you can
communicate during and after the
entrapment.
Get On the Ground
If time runs out while you are
attempting to escape, you must get
on the ground before the fire arrives
and finish deploying on the ground.
Keep your face next to the ground as
you pull the shelter over you. Death
is almost certain if the fire catches
you off the ground. The optimal
survival zone with or without a fire
shelter is within a foot of the ground.
Once you are entrapped, your
highest priority is to protect your
lungs and airway.
(With) any change in elevation
inside the shelter, there was a
drastic change in the
temperature. If you look at the
burn injuries that I received,
anything that was off the
ground and certainly the
things that were higher up in
the shelter (were) the areas
(where) I received the most
significant burns.
Entrapment survivor
Water Can Make
the Difference
The best way to use your water is to
drink it. Take canteens into your fire
shelter if you have time. Continue to
sip the water to replace lost fluids.
Sharing a Shelter
Never plan to share a shelter unless
someone is without one. The shelter
is designed for one person. Sharing
a shelter greatly increases your risk
of injury because it reduces the
amount of insulating airspace and
increases the chances your body will
contact hot shelter material. If you
canât avoid getting into someone
elseâs shelter, yell at them so they
know you are coming in. Always
enter from the side away from the
flames or hot air, so you donât
expose the occupant to the full force
of the wind and heat. Your head
should be by the other occupantâs
head.
Group Deployment
If you are with a group, deploy your
shelters close together. Adjacent
shelters can provide added
protection from radiant heat. In
addition, it will be easier to
communicate when the shelters are
close together. Optimal shelter
placement depends on the
conditions. Select the best
deployment sites available.
Deployment
It is extremely important that you
stay well hydrated when fighting fire.
Drink water often, during your shift
and when you are off duty. If you are
well hydrated, your body can sweat
and cool itself more effectively. This
is particularly important during an
entrapment.
Do not use your water to wet your
clothing or your bandanna inside the
fire shelter. Wet clothing conducts
heat to the skin more quickly than
dry clothing, so burns are more
likely. As the water on the clothing
evaporates, it increases the humidity
inside the shelter. Moist air will
cause more damage to your airway
than dry air at the same
temperature.
18
Do not delay
Do not delay
Do not delay
Do not delay
Do not delay
your
your
your
your
your
deployment.
deployment.
deployment.
deployment.
deployment.
Prepare for the
Prepare for the
Prepare for the
Prepare for the
Prepare for the
worst.
worst.
worst.
worst.
worst.
Keep These Items
Out of Your Fire
Shelter
Some flammable items, such as
fusees and gasoline, should not be
taken into the shelter. Throw them as
far away as possible when you
deploy your shelter. Fusees burn at
temperatures approaching 3,000 °F.
The temperatures inside the shelter
would rise quickly to fatal levels. You
should also keep tools, such as
pulaskis and shovels, away from the
shelter so they do not cut the shelter
material.
Throw your pack far away from the
shelter. The pack may contain
dangerous items, such as fusees.
Do Not Delay
Deployment
If you are entrapped, do not delay
your deploymentâprepare for the
worst.
If you have extra time, but cannot
escape to a safety zone, use the
time to increase your chances for
survival. Make sure that:
âą Everyoneâs shelter is out and
ready.
âą Everyone is wearing
appropriate personal protective
equipment including gloves,
hardhat, flame-resistant
clothing, boots, and if
available, face and neck
shrouds. If anyone lacks
equipment, survey the crew for
extra equipment.
âą Everyone knows where to
deploy. Use the extra time to
clear deployment sites to
mineral soil or to remove fuels
near the deployment area.
Deployment
Do not take
Do not take
Do not take
Do not take
Do not take
fusees inside
fusees inside
fusees inside
fusees inside
fusees inside
the shelter
the shelter
the shelter
the shelter
the shelter.
19
This was like a nuclear blast
occurring right over you and
youâre lying in tinfoil.
Entrapment survivor
O
O
nce you are in your shelter,
you must focus on two
things: staying on the
ground in the shelter no matter what,
and protecting your lungs and airway
by keeping your mouth as close to
the ground as possible. No matter
how bad it gets inside the shelter, it
will be much worse outside. If you
panic and leave the shelter, one
breath of hot gases can cause you
to suffocate. Turbulence can lift a
shelterâs edge, letting in hot gases.
Fires can generate winds of 50 miles
per hour or more, so you must hold
the shelter down firmly.
staying put. Control such feelings so
you can think clearly. Keep yourself
calm by concentrating your attention
on your breathing or on an object,
person, or religious symbol that is
meaningful to you. Mentally recite a
chant or phrase. These techniques of
meditation will help quiet your mind.
They can help reduce panic while
you remain alert.
You may be able to help calm other
trapped firefighters by shouting back
and forth, or by radio
communication. If someone yells at
you, try to let that person know
During an Entrapment
edges close to the ground. When the
shelter is not firmly on the ground,
your lungs will be vulnerable to hot
gases. Try not to breathe until your
face is against the ground. If you are
wearing a shroud, keep the front of
the shroud fastened to protect you if
heat enters the shelter.
Moving is risky. It may expose your
airway and lungs to hot flames and
gases. It may allow the shelter to fill
with smoke. Thereâs a chance of
losing your shelter in high winds
because itâs hard to hang onto it
when youâre moving. You can do little
to help another person during the
peak of an entrapment. Do not move
unless it is absolutely necessary.
Conditions Inside
the Shelter
In a prolonged entrapment or when
flames contact the shelter,
temperatures inside can rise to
uncomfortable, even dangerous,
levels. Your best chance for survival
is to stay calm and breathe the layer
of fresh air found at ground level.
Take short, shallow breaths.
The new fire shelter has fewer
pinholes than the old shelter. Even
so, firelight passing through pinholes
may appear to be hot coals or
embers on your clothing. These
openings do not reduce your
protection. No matter how big a hole
or tear your shelter may have, you
are better off inside the shelter.
In longer entrapments, or when
flames contact the shelter, the
shelter material can be hot enough
to burn you. This is why you should
be wearing a hardhat, flame-resistant
clothing, and gloves. Use your
When the first fire front came
across us, I would estimate
that the winds were probably
in excess of 70 miles per
hour. The sense of power that
you had around you, that
energy release that we had
around us was just absolutely
incredible. It was a very
humbling experience. I mean
you felt very small and very
insignificant at that point.
Entrapment survivor
youâre okay. If someone doesnât
respond to your shouts, do not leave
your shelter. During the fireâs peak,
the noise will be deafening. You may
be unable to hear anyone. Keep
calm. As soon as the noise
subsides, resume talking to each
other.
Moving Your
Shelter
You may want to move your shelter
when the flame front changes
position or to be closer to someone
in trouble. With your arms in the
holddown straps, move by crawling
on your belly, keeping the shelter
One of the other firefighters
began to pray out loud, and it
had almost a soothing effect at
that point, listening to him do
that.
Entrapment survivor
Entrapment can be extremely
frightening and may lead to panic.
Panic can cause firefighters to leave
their shelters and make a run for itâ
a far more hazardous gamble than
20
gloves to push the shelter material
away from your body, maintaining a
protective air gap. Shelter material is
most likely to contact your feet,
During an Entrapment
When the flame front hit, the
shelter was unbearable. I
cannot put in words what it was
like. It was just totally
unbearable. The only reason I
didnât get up and get out was
because I had enough sense to
realize it was a lot worse on the
outside.
Entrapment survivor
buttocks, head, elbows, and hands.
It is best to gently shift the points of
contact, especially around your feet
and elbows, because prolonged
contact will cause burns.
If flames contact the shelter, the
outer fabric heats up rapidly. The
adhesive may start to break down
allowing the foil on the outside of the
shelter to peel away and reducing
the shelterâs effectiveness. The inner
layer of foil prevents gases produced
by adhesive from getting inside the
shelter. Stay in your shelter with your
nose pressed to the ground. Your
flame-resistant clothing will provide
some protection.
We need to emphasize that to
people, that they may receive
injuries, but their greatest
hope is staying inside that
shelter and protecting
themselves, no matter what
they hear, no matter what they
see or feel, that they have to
make just an absolute
commitment to staying with
that shelter if they want to go
home.
Entrapment survivor
You do feel very isolated in there, and if
you hear anything at all, the things you
hear you donât want to hear, you wish
youâd never heard. And so itâs dark inside
the shelter, when the shelterâs down. Itâs
dark and youâre isolated and youâre alone
and, you know, youâve got those voices
out there for a few seconds, and when
that flame front hits, those go away.
Youâre by yourself all of a sudden.
Entrapment survivor
21
t was extremely painful. Things that were going through my head were, âIâm going to
die, this is going to kill me.â Afterwards, I remember thinking that because my legs
were burned on the back of both calves and the backs of my thighs and it was so
painful and it had gone on for such a long period of time that they were probably going to
have to amputate my legs.
You believe that youâre being burned
to death or that youâre being burned
to the point that youâd never be able
to use those limbs again, when in fact
[my injuries] were deep third degree
burns. But I ended up being able to
fully recover and not have any really
serious disability.
[We need to] make sure that people
know what they might encounter,
what it might be like, what they
might hear and see around them, and
to know above all else that if you get
up, you die.
I think people need to know that
youâre going to think youâre dying lying there on the ground, but in fact itâs probably not as
bad as you really think it is, and as long as you can protect your respiratory tract, youâre
probably going to walk away from this. People have to know that up front, going into this, or
theyâre just going to be surprised by it when they get in there and they start feeling these
things and they go, âOh, my God, Iâm dying. What do I do now?â You have to condition them
to know what the response to that should be, âOh, my God, Iâm dying. Well, they told me I
would. And, so I need to stay here.â
Entrapment survivor
I
I
During an Entrapment
22
I think for a period of probably 3 to 5
minutes I was absolutely sure that this
was it, that I was going to die in this,
that I would not survive this. There
was no question in my mind. It was
just a matter of whenâŠ. [Then] I
started to think about my family and
I remember thinking I need to do
everything that I possibly can to go
home and see them. And so thatâthat
really is what kept me in the shelter.
Entrapment survivor
During an Entrapment
When to Leave the
Shelter
There is no fixed time to stay under
your shelter. Donât move until the
flame front has passed. A drop in
noise, wind, and heat, and a change
in the color of light passing through
the shelter are tipoffs that itâs safe to
leave the shelter. Stay put until
temperatures have cooled
significantly or a supervisor tells you
When you leave your shelter, make
sure that your supervisor knows the
deployment occurred. Leave your
shelter and other equipment in place
if you can do so safely. A great deal
can be learned from reviewing the
circumstances of entrapments and
the performance of protective
equipment. Learning all we can from
each shelter deployment can help us
improve procedures and equipment
for all firefighters.
itâs safe to come out. Leaving a
shelter too soon can expose your
lungs to superheated air or dense
smoke. Typical entrapments have
lasted from 10 to longer than 90
minutes. Entrapments donât last as
long in light, flashy fuels as they do
in dense, heavy fuels. Firefighters
have died when they came out of
their shelters too soon. Stay inside a
little longer if you have any doubt
about leaving the shelter.
23
S
Training
S
econds are critical. Repeated
hands-on training in shelter
deployment is an essential
part of fire shelter training.
Firefighters have died when they
were unable to deploy their shelters
in time. Each year, every firefighter
should practice fire shelter drills
repeatedly. Drill until each step, from
dropping your gear to deploying your
shelter, can be done automatically.
Practice should allow you to deploy
the new shelter in 15 to 20 seconds.
Firefighters who have been through
entrapments have reported that
deploying the shelter had a calming
effectâthey were doing something
they had been trained to do. The
more you practice using your shelter,
the more likely you are to react
correctly in an emergency.
T
T
T
T
Train as
rain as
rain as
rain as
rain as
though
though
though
though
though
survival is at
survival is at
survival is at
survival is at
survival is at
stake.
stake.
stake.
stake.
stake.
It was obvious that [the
firefighters] had [trained] and
that they were comfortable
with the task, and it seemed to
sort of calm everybody down.
Entrapment survivor
I didnât say, âStart talking to
each other,â because I was
thinking âWell, I need to calm
these people down.â I was
thinking that because I was
trained to do that. I had been
told that in the training, âOnce
youâre in the shelters, begin to
talk to each other imme-
diately.â
Supervisor and
entrapment survivor
Training Scenarios
Each individual should practice
deploying the fire shelter under the
following six scenarios. It is best to
train in realistic field conditions.
Remember, always train wearing
gloves, a hardhat, a full pack, and if
you have one, a face and neck
shroud.
1. Standard deployment, clearing
a 4- by 8-foot site.
Practice a standard deployment,
first clearing a 4- by 8-foot site
to mineral soil. Practice
preparing the site so you can do
so quickly. Some firefighters have
found that the best way to deploy
the new shelter is to step in, sit
down, and roll over (figure 23).
2. Proper use of shake handles.
The handles that extend from
the end of the folded shelter
allow the shelter to be unfolded
quickly. When you grasp the
handles correctly, the shelterâs
opening will be toward your
body, allowing you to get inside
quickly. Practice looking at the
shake handles and grasping
them with the correct hands
before shaking.
3. Deploy your shelter while
lying on the ground.
If a fire approaches before you
are fully deployed, your most
important action is to get flat on
the ground. Practice deploying
your shelter from the ground by
opening the shelter and pulling it
over you.
4. Drop your gear and remove
your shelter while escaping.
When speed is essential for
escape, drop your gear and run
with just your fire shelter and
your tool. You are more likely to
remember these steps when
stress and fear set in during an
escape if you practice them
each year.
You can strip off the shelterâs
plastic bag as you are escaping.
A partially unfolded shelter can
be used as a heat shield and can
be fully deployed in a matter of
seconds. Be careful not to catch
the shelter on brush or rocks.
5. Deploy your shelter in a
strong wind.
Because fires are accompanied
by high winds and turbulence, it
is important to practice in these
conditions. Some people find it
easier to deploy from the ground
in strong winds. Try a variety of
deployment techniques to find
one that works for you. Always
remove your pack at the earliest
stage of deploymentâit is
extremely difficult to deploy a
fire shelter in the wind while you
are wearing a pack.
While windstorms provide the
most realistic training, you can get
a good feel for wind deployments
by using one or more strong fans,
such as the positive ventilation
fans used by fire departments.
24
6. Lie in your shelter.
Lie in your shelter and picture
yourself in an actual entrapment
situation. Fear of confined
spaces and the dark, combined
with extreme heat, turbulence,
and noise, can cause you to
panic. Imagine the sounds, heat,
and fear. Imagine steeling
yourself to pain and staying in
your shelter no matter what.
Some firefighters have suffered
claustrophobia while inside their
shelters. Spend enough time
inside a shelter to find out
whether youâre claustrophobic. If
you are, gradually increase the
time you spend inside a shelter
to help you adapt.
Practice Fire
Shelters
The new generation practice fire
shelters are made from green plastic
and can be reused many times. The
practice shelterâs carrying case is
orange. Never mix practice and real
fire shelter components. If you did,
someone could carry a practice
shelter to the fireline. This is another
reason to inspect your fire shelter
when you first receive it.
Figure 23âSome
firefighters have
found that the
best way to enter
the new shelter is
to step in, sit
down, and roll
onto your
stomach.
Step in
Sit down
Step in
Sit down
Training
Roll onto your stomach
Roll onto your stomach
25
Training should not be done
[under] controlled circum-
stances. Catch [firefighters]
when theyâre tired; catch them
when they are off guard; it may
be more similar to what itâs like
in the real world.
Supervisor and
entrapment survivor
Realistic Training
Is Best
The best training locations are in the
field where different deployment site
selections can be discussed.
Practice evaluating possible
deployment sites when out on the
fireline so you can recognize
deployment sites quickly, even when
you are under stress. Remember,
deployment requires removing your
pack, clearing a site, removing your
shelter, getting inside the shelter,
and deploying on the ground.
Never Train
in Live Fire
For more realism in training, some
crews have occupied shelters near
burning brush piles. This is
unacceptable. Such training is
extremely dangerous and risks
firefightersâ lives. NEVER use live
fire for fire shelter training.
Visualization
In addition to hands-on training,
visualize yourself practicing the
deployment scenarios. Think of
visualization as a dress rehearsal. It
is a form of practice that allows you
to experience events before they
happen. Images have a powerful
effect on us. The mind treats an
imagined entrapment as if it were
real. If you ever do have to drop your
pack and deploy your shelter,
visualization makes it more likely
that youâll react correctly, quickly,
and without panic. Visualization
should be used only to
supplementânever to replaceâ
hands-on training.
Picture yourself in different
entrapment situations. Think your
way through the entrapments and
imagine yourself reacting correctly to
each situation. The most important
actions to visualize are:
âą Dropping your pack and tools
to escape more quickly
âą Dropping dangerous items like
fusees and gasoline
âą Dropping to the ground before
the fire arrives
âą Getting under your shelter
âą Staying completely under your
shelter even if you are being
burned or the shelter starts to
fail
âą Protecting your airways and
lungs by remaining prone, with
your face to the ground
Training
26
Inspection and Care
Inspection
The shelter has an indefinite shelf
life because its materials do not
degrade in normal storage at the fire
cache. Nevertheless, all shelters
should be inspected when they are
issued and every 14 days during the
fire season. Only serviceable fire
shelters should be taken to the
fireline. Donât assume that a new
carrying case contains a new shelter.
Shelters with the oldest manufacture
dates should be issued first.
Inspect the carrying case, liner,
plastic bag, and shelter (figure 24).
Do not open the plastic bag. All
opened shelters should be removed
from service.
Check the plastic bag to ensure that
the quick-opening strip is unbroken
and the two red pull rings are intact.
Figure 24âInspect your shelter regularly.
If any item is broken, remove the
shelter from service.
Abrasion is the most common
damage to a fire shelter. Abrasion can
be spotted through the plastic bag.
Typically, the aluminum foil is rubbed
from the fiberglass cloth on the outer
surface or the outside edges of the
shelter. Remove the shelter from
service if you see extensive edge
abrasion, if aluminum particles have
turned the clear plastic bag dark gray
or black, or if the bottom of the bag
has debris. All of these problems are
signs of serious abrasion. Look for
tears along the folded edges. Remove
shelters from service when tears are
longer than Œ inch.
Shelters that have been removed
from service make excellent training
aids, but should be clearly marked
âFor Training Onlyâ so they do not
reach the fireline.
Care of the Fire
Shelter
Firefighting is rough on equipment,
so the fire shelter is expected to
have a limited service life. A little
care can extend that lifeâeven on
the fireline.
The shelter is an important piece of
protective equipment. Treat it
accordingly:
âą Always keep the shelter in its
hard plastic liner.
âą Avoid rough handling. Do not
lean against objects when you
are wearing the shelter. Do not
use the shelter as a pillow.
âą Donât load heavy objects on
top of the shelter.
âą Keep your shelter away from
sharp objects that may
puncture it.
27
A
Conclusions
A
s a firefighter, your highest
priority is to stay out of
situations that can lead to
entrapment. You must take
responsibility for your own safety.
You have an obligation to speak up if
you see something that is wrong,
and you have the right to be heard
without criticism. Remember, the fire
shelter does not guarantee your
safety. It is a last resort.
Take your training seriously. Practice
deploying your shelter until
deployment is, in the words of one
entrapment survivor, âlike tying your
shoe.â Think of training as life
insuranceâinsurance that if the
unthinkable ever occurs, you will
have every possible chance to
survive.
Feedback
We will continue to improve the fire
shelter and the fire shelter training
aids. Ideas for improvements come
primarily from you, the users. Please
send your ideas for improvements to
us.
Send comments and suggestions to:
Leslie Anderson
Missoula Technology &
Development Center
5785 Hwy. 10 West
Missoula, MT 59808-9361
Phone: 406â329â3900
Email: landerson@fs.fed.us
28
Notes:
29
Notes:
30
Notes:
About the Author
Leslie Anderson has been a project leader for the fire shelter and fire clothing projects since 1998.
She has a bachelorâs degree in forestry from the University of California, Berkeley, and a masterâs
degree in forestry from the University of Montana. She has worked in wildland fire since 1979, including
stints as a smokejumper and as a district assistant fire management officer on the Bitterroot National
Forest.
Library Card
Anderson, Leslie. Project leader. 2003. The new generation fire shelter. NWCG PMS 411. Boise, ID:
National Wildfire Coordinating Group, Fire Equipment Working Team, National Interagency Fire Center.
30 p.
An improved fire shelterâan emergency tent made of reflective materialâis now available for wildland
firefighters. The heavily illustrated report describes how firefighters should use their new fire shelter
when they are entrapped by fire. The report includes information on training, techniques to prevent
entrapments, and steps to take in case of an entrapment. In addition, it contains information on the
care and inspection of fire shelters.
Keywords: firefighting, personal protective equipment, safety at work
0351-2803-MTDC